自上料混凝土攪拌罐車的安全操作規程介紹!

 來源:http://www.rebetdrugs.com 日期:2021-09-13 發布人:jufeng
自上料混凝土攪拌罐車是將水泥,沙子,礫石骨料和水混合并將它們混合成混凝土混合物的機器。它主要由一個攪拌桶,一個給水/卸載機構,一個給水系統,一個原動機,一個傳動機構,一個框架和一個支撐裝置組成。只有安 全,合理地操作設備,才能提高設備的運行性能,因此下面的編輯器將介紹設備的安 全操作規則。
Self loading concrete mixer truck is a machine that mixes cement, sand, gravel, aggregate and water and mixes them into concrete mixture. It is mainly composed of a mixing drum, a water supply / unloading mechanism, a water supply system, a prime mover, a transmission mechanism, a frame and a support device. Only when the equipment is operated safely and reasonably can the operation performance of the equipment be improved. Therefore, the following editor will introduce the safe operation rules of the equipment.
1.駕駛之前,請仔細檢查車輛的狀況,以確??梢园?全行駛。
1. Before driving, please carefully check the condition of the vehicle to ensure safe driving.
自上料混凝土攪拌罐車
2.如果將自動上料攪拌車停在室外,則在裝載前需要顛倒攪拌桶以排出水和碎屑,以確?;炷恋馁|量。
2. If the automatic loading mixer is parked outdoors, the mixing drum needs to be reversed before loading to discharge water and debris to ensure the quality of concrete.
3.騙局運輸防滑釘時,請牢固放置傾斜的槽,以免因松動而晃動,傷害行人或影響其他行駛中的車輛的正常運行,同時防止混凝土溢出和污染。地面。
3. When transporting anti-skid nails by scam, please firmly place the inclined groove to avoid shaking due to looseness, hurting pedestrians or affecting the normal operation of other moving vehicles, and prevent concrete overflow and pollution. Ground.
4.自動上料攪拌車運輸混凝土所需的時間不得超過攪拌站規定的時間。在混凝土運輸過程中,請勿長時間停止攪拌桶,以防止混凝土偏析。駕駛員應不時觀察具體情況,向主控室報告異常情況,并提出處理要求。
4. The time required for the automatic loading mixer to transport concrete shall not exceed the time specified in the mixing plant. During concrete transportation, do not stop the mixing bucket for a long time to prevent concrete segregation. The driver shall observe the specific situation from time to time, report the abnormal situation to the main control room and put forward handling requirements.
5.如果車輛裝有混凝土,則現場停滯時間不應超過一小時。如果超時,現場人員將需要及時處理。
5. If the vehicle is equipped with concrete, the on-site dead time shall not exceed one hour. In case of overtime, the on-site personnel will need to deal with it in time.
6.當用混凝土攪拌機運輸未泵送的物料時,如果混凝土進入罐中到排出之間的溫度高,則不應超過2小時,并且必 須在2小時后排出。雨中溫度較低時,不應超過2.5小時。
6. When transporting non pumped materials with a concrete mixer, if the temperature between the concrete entering the tank and discharging is high, it shall not exceed 2 hours and must be discharged after 2 hours. When the temperature in the rain is low, it shall not exceed 2.5 hours.
7.瀝干混凝土之前,以10-12rpm的速度旋轉攪拌桶1分鐘,然后瀝干。
7. Before draining the concrete, rotate the mixing drum at the speed of 10-12 rpm for 1 minute, and then drain.
8.自上料混凝土攪拌罐車卸完后,立即使用連接到車輛的軟管沖洗入口,卸料斗和卸料斜槽,以清除車身上的污垢和殘留的混凝土,并保持車輛的衛生。
8. Immediately after the unloading of the loading concrete mixing tank truck, flush the inlet, unloading hopper and unloading chute with the hose connected to the vehicle to remove the dirt and residual concrete on the vehicle body and maintain the sanitation of the vehicle.
以上就是小編為大家介紹的相關內容,希望可以幫助到您,更多精彩內容可以直接關注http://www.rebetdrugs.com或者搜索:自上料混凝土攪拌罐車廠家都可以找到我們。
The above is the relevant content introduced by Xiaobian. I hope it can help you. More wonderful content can be directly concerned http://www.rebetdrugs.com Or search: we can be found by the manufacturer of concrete mixing tank truck since loading.