混凝土攪拌車罐體怎么維護?

 來源:http://www.rebetdrugs.com 日期:2021-05-07 發布人:admin
一、作為一臺混凝土攪拌機,首先要對混凝土攪拌機的箱體進行維護,并使用新的混凝土攪拌機將箱體支架實時固定在底盤框架附近。每次在運輸混凝土并進入清洗槽后,都須知道混凝土容易與鋼筋粘結。
1、 As a concrete mixer, first of all, it is necessary to maintain the box of the concrete mixer, and use a new concrete mixer to fix the box bracket near the chassis frame in real time. Every time after transporting the concrete and entering the cleaning tank, it is necessary to know that the concrete is easy to bond with the reinforcement.
山東梁山環球重工專用車股份有限公司
Shandong Liangshan global heavy industry Special Vehicle Co., Ltd
二、出料的對稱性是混凝土攪拌車的重要指標之一,直接影響施工質量。運輸混凝土時,攪拌筒的轉速應控制在2~5r/min。當混凝土坍落度較大,運輸間隔較長時,出料前應快速移動攪拌筒5~10次,使內部混凝土充分攪拌,大大提高出料的對稱性。
2、 Discharging symmetry is one of the important indexes of concrete mixer, which directly affects the construction quality. When transporting concrete, the rotation speed of mixing drum should be controlled at 2 ~ 5R / min. When the concrete slump is large and the transportation interval is long, the mixing drum should be moved quickly for 5 ~ 10 times before discharging, so that the internal concrete can be fully mixed and the symmetry of discharging can be greatly improved.
自上料混凝土攪拌罐車
如果混凝過程中失水,應在施工現場加水進行調解和充分攪拌。雖然這種環境應該停止,混凝土的質量將無法保證。有些用戶在運輸過程中不注意速度控制,過快會增加油耗,過小會造成混凝土離析。因此,攪拌筒的轉速應嚴格按照資質要求進行控制,以提高混凝土的運輸質量。
In case of water loss during coagulation, water should be added to the construction site for mediation and full mixing. Although this environment should stop, the quality of concrete will not be guaranteed. Some users do not pay attention to speed control during transportation, too fast will increase fuel consumption, too small will cause concrete segregation. Therefore, the rotation speed of the mixing drum should be strictly controlled according to the qualification requirements, so as to improve the transportation quality of concrete.
三、混凝土的至高不能高于儲罐的至大容積,因為混凝土的密度因強度等級的不同而不同。高強混凝土一般具有較高的密度,相同的體積對汽車不利。輸送混凝土的能力、質量和坍落度應符合車輛操作手冊的規定,并應實時加注潤滑油。
3、 The maximum height of concrete should not be higher than the maximum volume of storage tank, because the density of concrete varies with the strength grade. High strength concrete generally has high density, and the same volume is not good for cars. The capacity, quality and slump of concrete conveying shall comply with the provisions of vehicle operation manual, and lubricating oil shall be added in real time.
四、混凝土攪拌車停在露天時,裝載前應先將攪拌筒卸去旋轉,把水泥罐中的水放掉,以保證運輸混凝土的質量。
4、 When the concrete mixer truck is parked in the open air, the mixing drum should be removed and rotated before loading, and the water in the cement tank should be discharged, so as to ensure the quality of concrete transportation.
五、在高速公路上行駛時,應將卸料槽降至很低位置,隨車身一起轉移至垂直位置,并用鎖緊裝置將卸料槽鎖緊在車架上,以防因不安全而晃動,造成傷害和事故,影響其他車輛的運行。如果梯子狀況不好,會損壞油輪的油艙軸。
5、 When driving on the expressway, the unloading chute should be lowered to a very low position, and transferred to a vertical position with the body, and locked on the frame with a locking device, so as to prevent the shaking due to insecurity, causing injuries and accidents, and affecting the operation of other vehicles. If the ladder is not in good condition, the oil tank shaft of the tanker will be damaged.
六、卸料前,如果發現水分蒸發,坍落度偏低不能飽滿。當用戶需要時,可在攪拌筒中適當加水,然后根據進料偏差,以6~10轉/分鐘的速度旋轉30圈后,即可出料。
6、 Before unloading, if water evaporates, the slump is too low to be full. When the user needs, water can be added into the mixing drum properly, and then the material can be discharged after 30 turns at the speed of 6 ~ 10 RPM according to the feeding deviation.
七、混凝土攪拌車在運輸混凝土過程中不得將攪拌筒含動,以免出現混凝土離析現象。
7、 The concrete mixer truck shall not move the mixing drum in the process of transporting concrete to avoid concrete segregation.
購買產品重要的是質量,選擇商家選擇是誠信,自上料混凝土攪拌罐車真誠的為廣大客戶提供優良的服務,歡迎大家在網站:http://www.rebetdrugs.com 下方留言咨詢.
The most important thing to buy products is quality, and the choice of merchants is honesty. We sincerely provide excellent services for our customers. Welcome to visit our website: http://www.rebetdrugs.com  Below message consultation